Endre søk
RefereraExporteraLink to record
Permanent link

Direct link
Referera
Referensformat
  • apa
  • harvard1
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annet format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annet språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf
Reducing the Energy Use for Textiles in a Closed Cycle Tumble Dryer
Karlstads universitet, Fakulteten för teknik- och naturvetenskap, Avdelningen för energi-, miljö- och byggteknik.
2006 (engelsk)Manuskript (preprint) (Annet vitenskapelig)
sted, utgiver, år, opplag, sider
2006.
HSV kategori
Forskningsprogram
Miljö- och energisystem
Identifikatorer
URN: urn:nbn:se:kau:diva-2086OAI: oai:DiVA.org:kau-2086DiVA, id: diva2:6428
Tilgjengelig fra: 2007-03-13 Laget: 2007-03-13 Sist oppdatert: 2011-11-10bibliografisk kontrollert
Inngår i avhandling
1. Energy Efficient Textile Drying
Åpne denne publikasjonen i ny fane eller vindu >>Energy Efficient Textile Drying
2006 (Engelska)Licentiatavhandling, med artikler (Annet vitenskapelig)
Abstract [en]

Traditionally, textiles were dried outdoors with the wind and the sun enhancing the drying process. Tumble dryers offer a fast and convenient way of drying textiles independent of weather conditions. Tumble dryers, however, consume large amounts of electrical energy. Over 4 million tumble dryers are sold each year in Europe and a considerable amount of energy is used for drying of clothes. Increasing energy costs and the awareness about environmental problems related to a large energy use has increased the demand for dryers with better energy efficiency. The aim with this thesis is to show how to improve the energy efficiency of domestic tumble dryers.

Two types of tumble dryers are available on the market today: the open cycle dryer and the closed cycle dryer. In the open cycle dryer room air is heated and led into the drying drum. The exhaust air leaves the dryer and is often evacuated outside the building. In the closed cycle dryer an internal airflow is recirculated inside the dryer. When the hot air has passed through the drying drum it is led through a heat exchanger where the water vapour is condensed before the air is heated again and led to the drum. The heat exchanger is cooled with room air.

Drying at low temperature has been shown to reduce the specific energy use for an open cycle tumble dryer. In Paper I a correlation between the specific energy use, the drying time and the heat supply was established for a specific load by using the exhaust air temperature. It was shown that the total drying time and specific energy use could be predicted from data during the first hour of the process. This result indicated a possibility to create a control system that makes it possible for the user to choose between low energy use or short drying time.

The focus of Paper II is to reduce the energy use for a closed cycle tumble dryer. Energy and mass balances were established in order to determine feasible improvements. Energy and mass flows in the dryer indicated that reducing leakage from the internal system of the dryer gave the largest reduction of specific energy use. Insulation of the back cover of the dryer and opening the internal system during the falling drying rate period also gave positive results on the energy use. In total a feasible reduction of the energy use of approximately 17% was calculated.

sted, utgiver, år, opplag, sider
Fakulteten för teknik- och naturvetenskap, 2006
Serie
Karlstad University Studies, ISSN 1403-8099 ; 2006:61
Emneord
tumble dryer, drying, textile, energy and mass balance, control strategy
HSV kategori
Forskningsprogram
Miljö- och energisystem
Identifikatorer
urn:nbn:se:kau:diva-729 (URN)91-7063-092-5 (ISBN)
Presentation
2006-12-18, Sjöströmsalen, 1B 309, Karlstads Universitet, Karlstad, 10:15
Opponent
Veileder
Tilgjengelig fra: 2007-03-13 Laget: 2007-03-13

Open Access i DiVA

Fulltekst mangler i DiVA

Personposter BETA

Brunzell, Lena

Søk i DiVA

Av forfatter/redaktør
Brunzell, Lena
Av organisasjonen

Søk utenfor DiVA

GoogleGoogle Scholar

urn-nbn

Altmetric

urn-nbn
Totalt: 202 treff
RefereraExporteraLink to record
Permanent link

Direct link
Referera
Referensformat
  • apa
  • harvard1
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annet format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annet språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf